Spacesuit glitch cuts spacewalk short at space station

Endeavour astronaut Andrew Feustel works on the exterior of the International Space Station during Friday's spacewalk, which was cut short due to a spacesuit sensor failure.
Endeavour astronaut Andrew Feustel works on the exterior of the International Space Station during Friday's spacewalk, which was cut short due to a spacesuit sensor failure.AP
/ Source: Space.com

Two Endeavour astronauts took a spacewalk on Friday to upgrade the International Space Station, but had to cut their work short when a spacesuit sensor that detects carbon dioxide levels failed.

Astronauts Andrew Feustel and Greg Chamitoff spent more than five hours working outside the space station to replace science experiments, install new equipment and perform maintenance on the orbiting laboratory. They planned to spend about six and a half hours on the tasks, but NASA ordered them to end the spacewalk slightly early because of the broken sensor on Chamitoff's spacesuit. [Infographic: Spacesuit Fashion Evolution]

The glitch occurred when a sensor that monitors the level of carbon dioxide inside Chamitoff's suit failed. Without this sensor, mission controllers had no way of knowing for sure how much oxygen he had left.

After doing a conservative estimate, NASA managers determined that there wouldn't be enough time for Chamitoff and Feustel to connect a series of cables, so Mission Control instructed the spacewalkers to clean up and call it a day early. One unfinished task can be completed on a future spacewalk, officials said.

Friday's spacewalk began when the astronauts opened the hatch of the station's airlock and floated outside at 3:10 a.m. ET. It was the first of four spacewalks planned for Endeavour's STS-134 mission, which is the orbiter's last spaceflight before it is retired to a museum. [Photos of Space Endeavour's Final Launch]

While the spacewalkers were working, NASA continued investigating two small areas of damage on Endeavour's heat shield tiling. The damage will likely not pose any risk to the orbiter, but more analysis is needed to know for sure.

Taz's first spacewalk
Friday's outing was the first spacewalk for Chamitoff (nicknamed "Taz"), who spent about six months living on the space station in 2008, but never got a chance to float outside a spacecraft. Feustel has performed three previous spacewalks. [Video: Endeavour's Liftoff into History]

"Drew, I just wanted to say welcome back to open space, and Taz, congratulations on being the 201st human being to be in outer space," their crewmate, Mike Fincke, said from inside the space station. "I waited a long time to say those words to you."

"It is a dream come true for me," Chamitoff replied. "It would be for anybody, the first or the 201st."

"Welcome to space, buddy," Feustel said.

The spacewalkers' main goal for the day was to remove samples from an experiment called MISSE (Materials International Space Station Experiment), which tests the reaction of different materials, such as paints, plastics, circuits and even seeds, in the environment of space.

"A beautiful MISSE experiment," Feustel said upon arriving at the scene.

Science swapping
Feustel and Chamitoff retrieved a set of samples that had been exposed to space for about a year, and stowed them in the shuttle's cargo bay to be returned to Earth for analysis. They replaced the samples with a fresh batch that will be left out for at least six months.

"That is also another major mission objective milestone, so congratulations," said Fincke, who was coaching the spacewalkers from inside the space station.

The astronauts also installed a protective cover on a joint that controls the movement of one of the space station's solar arrays, and did some prep work for the mission's second spacewalk on Sunday, which will focus on topping off ammonia coolant in a leaking system.

"All right, boys, keep up the good work," Fincke said after they had completed this task. "This is a lot of fun."

One of their final tasks was to install a set of new communications antennas on the space station's Destiny laboratory.

The spacewalkers were able to attach these successfully, but they were unable to install a set of connection cords because time ran out.

Focused inspection
On Saturday, NASA may decide to schedule a focused inspection of the damaged areas on Endeavour's heat shield tiles so astronauts can gather more pictures for analysis.

The astronauts on the space station will also have a phone call with Pope Benedict XVI from the Vatican. Two Italian astronauts — station crewmember Paolo Nespoli and shuttle astronaut Roberto Vittori — are currently in space.

Endeavour's crew is in the midst of a 16-day mission to the space station to deliver a $2 billion astrophysics experiment and other supplies to the orbiting lab. The experiment, known as the Alpha Magnetic Spectrometer, was successfully installed on Thursday.

By the time all was said and done, Friday's spacewalk officially lasted six hours and 19 minutes, bringing Feustel's total career spacewalking time so far to 27 hours, 17 minutes (Chamitoff now has a total of six hours, 19 minutes).

It was the 115th spacewalk outside of the International Space Station's airlock, and the 156th spacewalk to build the space station. That brings the total spacewalking time spent constructing the station to 980 hours and 12 minutes.

You can follow SPACE.com senior writer Clara Moskowitz on Twitter @. Visit SPACE.com for complete coverage of or follow us and on .